Enhancing the Retention and Oxidative Stability of Volatile Flavors: A Novel Approach Utilizing O/W Pickering Emulsions Based on Agri-Food Byproducts and Spray-Drying.

Spray-drying is a commonly used method for producing powdered flavors, but the high temperatures involved often result in the loss of volatile molecules. To address this issue, our study focused on a novel approach: developing O/W Pickering emulsions with agri-food byproducts to encapsulate and protect D-limonene during spray-drying and storage. Emulsions formulated with lupin hull, lupin-byproduct (a water-insoluble protein-fiber byproduct derived from the production of lupin protein isolate), and camelina press-cake were subjected to spray-drying at 160 °C. The results revealed that these emulsions exhibited good stability against creaming. The characteristics of the dry emulsions (powders) were influenced by the concentration of byproducts. Quantitative analysis revealed that Pickering emulsions enhanced the retention of D-limonene during spray-drying, with the highest retention achieved using 3% lupin hull and 1% camelina press-cake. Notably, lupin-stabilized emulsions yielded powders with enhanced oxidative stability compared to those stabilized with camelina press-cake. Our findings highlight the potential of food-grade Pickering emulsions to improve the stability of volatile flavors during both processing and storage.

Comparative Study of Food-Grade Pickering Stabilizers Obtained from Agri-Food Byproducts: Chemical Characterization and Emulsifying Capacity.

Natural Pickering emulsions are gaining popularity in several industrial fields, especially in the food industry and plant-based alternative sector. Therefore, the objective of this study was to characterize and compare six agri-food wastes/byproducts (lupin hull, canola press-cake, lupin byproduct, camelina press-cake, linseed hull, and linseed press-cake) as potential sources of food-grade Pickering stabilizers. The results showed that all samples contained surface-active agents such as proteins (46.71-17.90 g/100 g) and dietary fiber (67.10-38.58 g/100 g). Canola press-cake, camelina press-cake, and linseed hull exhibited the highest concentrations of polyphenols: 2891, 2549, and 1672 mg GAE/100 g sample, respectively. Moreover, the agri-food byproduct particles presented a partial wettability with a water contact angle (WCA) between 77.5 and 42.2 degrees, and they were effective for stabilizing oil-in-water (O/W) emulsions. The emulsions stabilized by Camelina press-cake, lupin hull, and lupin by-product (≥3.5%, w/w) were highly stable against creaming during 45 days of storage. Furthermore, polarized and confocal microscopy revealed that the particles were anchored to the interfaces of oil droplets, which is a demonstration of the formation of a Pickering emulsion stabilized by solid particles. These results suggest that agri-food wastes/byproducts are good emulsifiers that can be applied to produce stable Pickering emulsions.

Assessment of the Nutritional Value of Traditional Vegetables from Southern Chile as Potential Sources of Natural Ingredients.

There is an increasing interest in consuming healthy foods motivated by the need of boosting the immune system naturally. In this sense, vegetables rich in bioactive compounds are a clear example of "superfoods" that promotes overall health and strengthen the immune response. Therefore, in this study eight traditional vegetables usually produced in southern Chile (pea, corn, carrot, leek, spinach, chard, coriander and parsley) were characterized in terms of their nutritional composition to evaluate their potential as lyophilized natural ingredients. Thus, chemical composition, amino acid profile, minerals, vitamins, carotenoids, polyphenols and pesticide residues were evaluated. Green leafy vegetables resulted to be an excellent source of proteins and dietary fibers as well as vitamins (ascorbic acid, choline, alpha-tocopherol and niacin), minerals (calcium, phosphorus and iron), carotenoids and polyphenols. Among the eight vegetables assessed spinach exhibited the more balanced nutritional profile. Moreover, 332 pesticide residues were analysed and only six were detected in a low concentration. Due to their nutritional properties, the present results suggest that vegetables produced in southern Chile could be considered as promising alternatives to develop natural food ingredients.

Synthesis of New Chitosan from an Endemic Chilean Crayfish Exoskeleton (Parastacus Pugnax): Physicochemical and Biological Properties.

Chitin is one of the most abundant natural polysaccharides in the world and it is mainly used to produce chitosan by a deacetylation process. In the present study, the extraction of chitin and chitosan from the Parastacus pugnax (P. pugnax) crayfish exoskeleton was studied for the first time. Thus, the P. pugnax crayfish exoskeleton was converted to chitosan following the steps of depigmentation, deproteinization, and deacetylation. The produced chitosan (Chitosan-CGNA) was characterized in terms of the protein content, solubility, degree of deacetylation, viscosity, molecular weight, FTIR, SEM, XRD, antimicrobial, and antioxidant activity. The results showed that the obtained chitosan had a high degree of deacetylation (91.55%) and a medium molecular weight (589.43 kDa). The antibacterial activity of the chitosan was tested against bacterial strains relevant for the food industry and the lowest minimum inhibitory concentration (MIC) values were evidenced with Salmonella tiphymurium (S. typhimurium), Staphylococcus aureus (S. aureus), Enterococcus faecalis (E. faecalis) and Listeria. Monocytogenes (L. monocytogenes). Moreover, the Chitosan-CGNA showed an effect on DPPH radical scavenging activity, and its antioxidant activity was dependent on concentration and deacetylation degree. These results suggest that P. pugnax exoskeleton could be an excellent natural source for the production of chitosan with potential applications in the health system, and to prevent infections associated with pathogens strains.

Effect of Interfacial Ionic Layers on the Food-Grade O/W Emulsion Physical Stability and Astaxanthin Retention during Spray-Drying.

The utilization of astaxanthin in food processing is considered to be narrow because of its substandard solubility in aqueous matrices and the instability of chemical compounds during the processing of food and the instability of chemical compounds during the processing of food. The investigation sought to evaluate multilayer emulsions stabilized by ionic interfacial layers of lupin protein isolate (LPI), ι-carrageenan (CA), and chitosan (CHI) on the physical stability of the emulsion as well as the retention of astaxanthin during the spray drying process. Primary emulsion (Pr-E) was prepared by adding LPI on oil droplet surfaces containing astaxanthin. The homogenization pressure and cycles to obtain the Pr-E were investigated. The secondary emulsion (Se-E) and tertiary emulsion (Te-E) were elaborated by mixing CA/Pr-E and CHI/Se-E, respectively. Emulsion stability was assessed under different environmental stresses (pH and NaCl). Astaxanthin retention of emulsions was determined immediately after finishing the spray-drying process. The results showed that Pr-E was stabilized with 1.0% (w/v) of LPI at 50 MPa and three cycles. Se-E and Te-E were obtained with CA/Pr-E and Se-E/CHI of 70/30 and 50/50% (w/w), respectively. The Se-E was the most stable compared to the Pr-E and Te-E when subjected to different pHs; nevertheless, once the NaCl concentration rose, no variations in the ζ-potential of all emulsions studied or destabilization were observed. The Se-E and Te-E derived provided higher astaxanthin retention (>95%) during the spray-drying process compared to Pr-E (around 88%). The results indicated that these astaxanthin multilayer emulsions show considerable potential as a functional ingredient in food products.

Food-grade Pickering emulsion as a novel astaxanthin encapsulation system for making powder-based products: Evaluation of astaxanthin stability during processing, storage, and its bioaccessibility.

The use of astaxanthin as a food ingredient is limited due to its poor water solubility in aqueous matrices and highly susceptibility to oxidation; hence microencapsulation of this carotenoid is an appropriate technique to increase its stability and functionally. In this study, astaxanthin oleoresin was encapsulated using a food-grade Pickering emulsion to enhance its stability during spray-drying and storage and its bioaccessibility. The oil-in-water (O/W) emulsions were stabilized by protein-based aggregates obtained from a lupin protein-rich cultivar (AluProt-CGNA). The emulsions containing the astaxanthin microencapsulated in its oil phase (core material) were submitted to a spray-drying process at 160 °C and 140 °C. For this, blends of these protein-based aggregates (LP-APs) and maltodextrin (at different ratios) were used as wall material. The emulsion stability, microstructure, powder characteristics, oxidative stability and concentration of astaxanthin, encapsulation efficiency and bioaccessibility after spray-drying were investigated. The results showed that LP-APs exhibit a great potential to perform as stabilizers for Pickering emulsions. The formed O/W emulsions were highly stable against creaming at high concentrations of LP-APs. The results also indicated that spray-drying can be applied to prepare stable astaxanthin emulsions into powders with good oxidative stability. The astaxanthin content in dry emulsions under storage conditions (25 and 45 °C for 4 weeks) was higher in powders containing a higher LP-APs concentration. The encapsulation efficiency was higher than 90% with the emulsion stabilized with 6% of LP-APs. The bioaccessebility of reconstituted astaxanthin powder (with 6% LP-APs) was around 80%.

Probiotics as an Adjunct Therapy for the Treatment of Halitosis, Dental Caries and Periodontitis.

Probiotics and prebiotics are popular among consumers worldwide as natural approaches to prevent gastrointestinal diseases. The effects of their consumption on the gastrointestinal system have been extensively investigated. Recently, the efficacy of probiotics and prebiotics has been evaluated against naturally developing microbiome imbalance in the human body, such as in the oral cavity, skin, female urogenital tract, and respiratory tract. This review examines the scientific data related to the effects of probiotics on the treatment of diseases occurring in the oral cavity. Probiotics can effectively prevent and treat some infectious diseases in the oral cavity, such as halitosis and periodontitis, and can reduce the development of dental caries and the concentration of harmful bacteria, according to clinical studies. The results of this meta-analysis also suggest the use of probiotics to treat halitosis and periodontitis. However, the evidence may be inconclusive due in part to the use of a wide range of probiotics, non-standardized study design, small population size, poor quality reports, and inconsistent data. Therefore, future studies should homogenize terms and definitions for primary and secondary outcomes, increase the number of volunteers/patients in in vitro tests and clinical studies, and include an evaluation of the combined use of pre- and probiotics.

Probiotics and prebiotics potential for the care of skin, female urogenital tract, and respiratory tract.

The prebiotics and probiotics market is constantly growing due to the positive effects of its consumption on human health, which extends beyond the digestive system. In addition, the synbiotic products market is also expanding due to the synergistic effects between pre- and probiotics that provide additional benefits to consumers. Pre- and probiotics are being evaluated for their effectiveness to treat and prevent infectious diseases in other parts of the human body where microbial communities exist. This review examines the scientific data related to the effects of pre- and probiotics on the treatment of diseases occurring in the skin, female urogenital tract, and respiratory tract. The evidence suggests that probiotics consumption can decrease the presence of eczema in children when their mothers have consumed probiotics during pregnancy and lactation. In women, probiotics consumption can effectively prevent recurrent urinary tract infections. The consumption of synbiotic products can reduce respiratory tract infections and their duration and severity. However, the outcomes of the meta-analyses are still limited and not sufficiently conclusive to support the use of probiotics to treat infectious diseases. This is largely a result of the limited number of studies, lack of standardization of the studies, and inconsistencies between the reported results. Therefore, it is advisable that future studies consider these shortcomings and include the evaluation of the combined use of pre- and probiotics.

Chemical and Nutritional Evaluation of Protein-Rich Ingredients Obtained through a Technological Process from Yellow Lupin Seeds (Lupinus luteus).

In recent years, interest in plant-based proteins has been rising due to ethical and sustainability issues. In this context, the production of protein concentrates and isolates from new plant sources have increased enormously because of their nutritional and techno-functional properties. Therefore, this work describes a pilot process for obtaining protein-rich ingredients from a yellow lupin variety (Lupinus luteus) developed by the Agriaquaculture Nutritional Genomic Center (CGNA). A protein alkaline solubilisation followed by isoelectric precipitation was used as a method for obtaining a protein concentrate (LPC) and isolate (LPI) with 75 and 95% protein, respectively. The changes in the protein quality and chemical composition during the protein concentration process from lupin flour were evaluated. Thus, nutritional parameters such as the amino acids (AAs) profile, essential amino acid index (EAAI), chemical score (CS), the protein efficiency ratio (PER), and digestible indispensable amino acid score (DIAAS) were determined to evaluate the nutritional quality of LPC and LPI. The facile and scalable protein isolation method without a defatting process proposed in this study showed a great protein separation efficiency (PSE), while the amino acids profile was not affected during both the concentration as well as the isolation of proteins. In addition, SDS-PAGE showed that both LPC and LPI mainly contained the high-molecular-weight proteins α and ß-conglutins. Both LPC and LPI had a balanced amino acids profile, and arginine was the most predominant amino acid. These results are useful for increasing the use of lupin based-protein ingredients as a potential functional ingredient in the food industry.

Volatile and non-volatile/semi-volatile compounds and in vitro bioactive properties of Chilean Ulmo (Eucryphia cordifolia Cav.) honey.

Ulmo honey originating from Eucryphia cordifolia tree, known locally in the Araucania region as the Ulmo tree is a natural product with valuable nutritional and medicinal qualities. It has been used in the Mapuche culture to treat infections. This study aimed to identify the volatile and non-volatile/semi-volatile compounds of Ulmo honey and elucidate its in vitro biological properties by evaluating its antioxidant, antibacterial, antiproliferative and hemolytic properties and cytotoxicity in Caco-2 cells. Headspace volatiles of Ulmo honey were isolated by solid-phase microextraction (SPME); non-volatiles/semi-volatiles were obtained by removing all saccharides with acidified water and the compounds were identified by GC/MS analysis. Ulmo honey volatiles consisted of 50 compounds predominated by 20 flavor components. Two of the volatile compounds, lyrame and anethol have never been reported before as honey compounds. The non-volatile/semi-volatile components of Ulmo honey comprised 27 compounds including 13 benzene derivatives accounting 75% of the total peak area. Ulmo honey exhibited weak antioxidant activity but strong antibacterial activity particularly against gram-negative bacteria and methicillin-resistant Staphylococcus aureus (MRSA), the main strain involved in wounds and skin infections. At concentrations >0.5%, Ulmo honey reduced Caco-2 cell viability, released lactate dehydrogenase (LDH) and increased reactive oxygen species (ROS) production in a dose dependent manner in the presence of foetal bovine serum (FBS). The wide array of volatile and non-volatile/semi-volatile constituents of Ulmo honey rich in benzene derivatives may partly account for its strong antibacterial and antiproliferative properties important for its therapeutic use. Our results indicate that Ulmo honey can potentially inhibit cancer growth at least partly by modulating oxidative stress.

Production of eicosapentaenoic acid by Nannochloropsis oculata: Effects of carbon dioxide and glycerol.

The marine microalga Nannochloropsis oculata is a potential source of eicosapentaenoic acid (EPA, C20:5n3) and carotenoids for use in functional foods and nutraceuticals. Mixotrophic culture of N. oculata using glycerol was examined as a possible way of increasing the biomass and metabolite productivity relative to a pure photoautotrophic culture in modified f/2 medium. The effect of CO2 supply was also tested. EPA production in semi-continuous culture with and without glycerol and CO2 was evaluated. The effects of glycerol supplementation and light/dark cycling on the production of the biomass and EPA are reported for cultures conducted at a constant pH controlled using CO2. Consumption of glycerol was small, but its effects were significant. Glycerol enhanced the lipid content of the biomass but reduced the chlorophyll a content. Mixotrophic cultivation favored the production of lipids with a high percentage of saturated fatty acids that are generally desired in oils for making biodiesel. EPA concentration (5.3±0.6 to 27.5±1.6mg EPA/L) in N. oculata cultures depended strongly on growth conditions. The highest EPA concentration occurred in non-aerated mixotrophic culture with intermittent CO2 supply without pH control. This EPA concentration (=27.5±1.6mg/L) was comparable to that obtained in semi-continuous culture without glycerol and pH control, and aerated with CO2 enriched air during the light period (=23.6±1.1mg/L).

Emulsifying and Foaming Properties of Different Protein Fractions Obtained from a Novel Lupin Variety AluProt-CGNA(®) (Lupinus luteus).

The use of vegetable proteins as food ingredient is becoming increasingly important due to their high versatility and environmental acceptability. This work describes a chemical characterization and techno-functional properties (emulsifying and foaming properties) of 3 protein fractions obtained from a protein-rich novel lupin variety, AluProt-CGNA(®) . This nongenetically modified variety have a great protein content in dehulled seeds (60.6 g protein/100 g, dry matter), which is higher than soybean and other lupin varieties. A simple procedure was utilized to obtain 3 different fractions by using alkali solubilization and isoelectric precipitation. Fractions 1 and 3 were mainly composed of protein and polysaccharides (NNE), whereas fraction 2 was mainly composed by protein (97%, w/w). Fraction 3 presented interesting and potential foaming properties in comparison to the other fractions evaluated in the study. Besides, its solubility, foaming and emulsifying capacity were practically not affected by pH variations. The 3 fractions also presented good emulsion stability, reaching values above a 95%. SDS-PAGE showed that fractions 1 and 2 contained mainly conglutin α, ß, and δ, but in different ratios, whereas fraction 3 contained mainly conglutin γ and albumins. The results of this work will provide better understanding for the utilization of each protein fractions as potential ingredients in food industry.

Functional and physicochemical properties of a protein isolate from AluProt-CGNA: A novel protein-rich lupin variety (Lupinus luteus).

This study describes the isolation of proteins from the novel lupin variety AluProt-CGNA (Lupinus luteus) and the influence of pH and NaCl on their functional properties. AluProt-CGNA variety showed to have a great protein content in dehulled seeds (60.60g protein/100g, dry matter), which is higher than soybean and other lupin varieties. A lupin protein isolate (97.54g protein/100g) from AluProt-CGNA, LPIA, was prepared from lupin flour by alkali solubilization and isoelectric precipitation. The solubility profile of the LPIA was affected by pH, where the minimal values were observed at pH values close to its isoelectric point range (pH4-5). The highest values of water absorption capacity (1.71cm3H2O/g protein), oil absorption capacity (1.43g trapped oil/g protein), emulsifying capacity (61.94%), emulsion stability (96.43%), foaming capacity (114.29%), foam stability (65.69%) and least gelation concentration (20g/100cm3) were observed at pH values lower and higher than its isoelectric point. In the presence of 100mM of NaCl, their functional properties were improved. SDS-PAGE showed that LPIA mainly contained high molecular weight proteins (α and ß-conglutin). These results are useful for increasing the utilization of this protein isolate as a potential functional ingredient in food industry.

In vitro study of the cytotoxicity and antiproliferative effects of surfactants produced by Sphingobacterium detergens.

The application of biosurfactants in the biomedical field is growing due to their antimicrobial activity, low cytotoxicity and ability to induce apoptosis in cancer cells. In the light of this therapeutic potential, as well as possible applications in cosmetics or as drug vehicles in pharmaceutical products, a new biosurfactant produced by Sphingobacterium detergens was investigated for its haemolytic activity and cytotoxic and antiproliferative effects in different cell lines. Fraction A showed 100% haemolysis in rabbit erythrocytes, but in Fraction B the rate was only 83%. When comparing cytotoxicity values (IC50) of the two fractions in model fibroblast and keratinocyte cell cultures, Fraction B was less cytotoxic, showing lower values than the reference compound SDS, indicating low skin irritability. Finally, in non-differentiated intestinal Caco-2 cultures, Fractions A and B reduced cell proliferation and induced apoptosis by 44% and 75%, respectively. According to these results, biosurfactants produced by S. detergens have potential application in cosmetic and pharmaceutical formulations.

Sphingobacterium detergens sp. nov., a surfactant-producing bacterium isolated from soil.

A novel Gram-negative-staining strain, designated 6.2S(T), was isolated from a soil sample and identified as a biosurfactant producer. Its taxonomic position was investigated using a polyphasic approach. The cells were non-motile, non-spore-forming rods. The organism grew optimally at 30-37 °C, with 0-3% (w/v) NaCl, and at pH 7.0. Based on 16S rRNA gene sequence analysis, strain 6.2S(T) was found to be a member of the genus Sphingobacterium and was most closely related to four type species of the genus, showing sequence similarities of 96.8-98.9%. Partial chaperonin 60 (cpn60) gene sequence analysis was useful in resolving the phylogenetic relationships between strain 6.2S(T) and closely related taxa, with similarities ranging from 85.5% (with Sphingobacterium thalpophilum DSM 11723(T)) to 90.3% (with Sphingobacterium canadense CR11(T) and Sphingobacterium multivorum JCM 21156(T)). The results of DNA-DNA hybridization experiments between the novel strain and its closest relatives gave a DNA-DNA relatedness value of less than 70%, and consequently confirmed that this new strain did not belong to a previously described species of the genus Sphingobacterium. The major fatty acids were summed feature 3 (iso-C(15:0) 2 OH and/or C(16:1)ω7c); iso-C(15:0); iso-C(17:0) 3-OH and C(16:0). The G+C content of the genomic DNA was 40.0 mol%. According to its phenotypic and genotypic characteristics and the phylogenetic data, strain 6.2S(T) represents a novel species of the genus Sphingobacterium, for which the name Sphingobacterium detergens sp. nov. is proposed. The type strain is 6.2S(T) ( = CECT 7938(T) = LMG 26465(T)).